Wenhao, Junwei, Add to Mendeley. https://doi/10.1016/j.ijmst.2022.09.018 Get rights and content. Under a Creative Commons license. open access. Abstract. The …
ادامه مطلبPrevious studies have proved that the lead complexes of benzohydroxamic acid (Pb–BHA) are effective collectors of scheelite flotations; however, the separation of scheelite from calcite needs depressants with high selectivity. In this study, we reported a novel depressant for calcite minerals, and Pb–BHA served as the collector of scheelite. …
ادامه مطلبAn interesting separation of calcite and other minerals at pH values near 4 has been demonstrated. Despite the fact calcite begins to dissolve itself at pH values below 4, the pK a of the carboxylic functions of sulphosuccinamate is approximately pH 7.6. At pH 4, the main form of the carboxylic function of sulphosuccinamate is the molecular form.
ادامه مطلبEffect of mixed OPS/BHA on selective flotation of scheelite from calcite was attempted. • Single mineral and mixed mineral flotation tests were conducted at pH 9. • Scheelite/calcite separation was achieved using mixed OPS/BHA collectors. • Zeta potential and contact angle experiments confirmed the flotation results in this study.
ادامه مطلبThe central problem for direct flotation of oxidized zinc ores is poor selectivity, which is needed to separate gangue minerals into concentrate. Calcite is a common …
ادامه مطلبTo verify the separation performance of smithsonite from calcite with PA, the flotation experiments of mixed minerals (the mass ratio of smithsonite and calcite was 1:1) were conducted based on the optimized conditions determined by the single mineral flotation experiments. Separation efficiency (SE) was used to evaluate the flotation ...
ادامه مطلبZinc oxide minerals (primarily smithsonite and hemimorphite) are important sources of Zn. Flotation is the most widely used method of enriching zinc oxide minerals for mineral processing. Chelating reagents have received extensive attention for the flotation of zinc oxide ores because of their high selectivity and stability. This paper systematically …
ادامه مطلبThe properties of calcite make it one of the most widely used minerals. It is used as a construction material, abrasive, agricultural soil treatment, construction aggregate, pigment, pharmaceutical and more. It has more uses than almost any other mineral. Calcite in the form of oolitic limestone from Bedford, Indiana.
ادامه مطلبIn this paper, the potential of sulfonated naphthalene formaldehyde (SNF) condensate as a depressant in the flotation separation of scheelite from calcite was verified and investigated. The results of microflotation experiments showed that SNF had a stronger depressant performance on calcite than a conventional depressant—water glass and …
ادامه مطلبCalcite is a semi-soluble mineral that can be considered one of the main problematic gangue phases for several different types of valuable sulfides and oxides. Since froth flotation is the main beneficiation technique for upgrading these valuable minerals, calcite flotation separation has been widely investigated.
ادامه مطلبThe specific gravity of RE minerals is relatively high (2.9–7.2), while the density of gangue minerals (mainly silicate) is low. Therefore, gravity separation is an important technique for concentrating RE minerals. 51, 52 Extensively used gravity separation devices include shaking tables, conical separators, and spiral concentrators.
ادامه مطلبIn this study, a novel reagent schedule using citric acid (CA) as the depressant, sodium fluoride (NaF) as the regulator and sulfoleic …
ادامه مطلبThe separation of carbonate gangue minerals, such as dolomite and calcite, from phosphate ores, like apatite, is still a notorious problem in mineral processing (Wonyen et al., 2018; Yehia et al ...
ادامه مطلبIn this study, the flotation separation of cassiterite and the typical gangue mineral, calcite, was investigated using the metal-inorganic complex depressant AlSS, …
ادامه مطلبIn a mineral system composed of calcite, fluorite, and barite, Zijie et al. (2017) studied the feasibility to selectively separate the three minerals using the Valonea extract as the biobased ...
ادامه مطلبIn the flotation separation of artificially mixed minerals, malachite could be separated successfully from calcite at pH around 9.0 when using Na 2 S as a regulator. Its adsorption mechanism was also studied by FT-IR, zeta potential and XPS measurements, all of which confirmed that CMDTP showed a better affinity to malachite surface than to ...
ادامه مطلبThese minerals are generally separated by flotation and/or magnetic separation (in the case of iron impurities). Calcite ores typically contain metal sulphide, silicate, or other calcium ...
ادامه مطلبThe flotation separation of smithsonite and calcite is difficult due to their similar surface properties. In this study, cupferron was applied as a collector to realize the separation of smithsonite and calcite. Micro-flotation experiment results indicated that smithsonite and calcite express different floatability after treatment with cupferron. The …
ادامه مطلبCa mineral flotation was performed to characterise the separation conditions of calcite, francolite, fluorite and gypsum at neutral pH. These minerals constitute the gangue of metallic or sedimentary ores. The separation of Ca minerals is difficult because of their similar surface properties.
ادامه مطلب@article{osti_1885339, title = {Improving Rare-Earth Mineral Separation with Insights from Molecular Recognition: Functionalized Hydroxamic Acid Adsorption onto Bastnäsite and Calcite}, author = {Chapleski, Robert C. and Chowdhury, Azhad U. and Wanhala, Anna K. and Gibson, Luke D. and Stamberga, Dia̅na and Jansone-Popova, …
ادامه مطلبCalcite is another common Ca-containing gangue mineral associated with bastnaesite. Previous works show that the flotation separation of bastnaesite and calcite has the greater difficulty than that of bastnaesite and fluorite using NHAs, and that the heavy use of depressant is therefore needed [43].
ادامه مطلبFortunately, researchers have made substantial progress in separating the minerals of scheelite by using depressants. This study reviews the application and …
ادامه مطلبIt is known that the flotation separation of fluorite/calcite is extremely difficult because of their similar surface features. In this research, the combination of FeSO 4 ·7H 2 O and …
ادامه مطلبFlotation separation of scheelite from calcite using mixed collectors. International Journal of Mineral Processing, 169, 106-110. Zhang W., Honaker R.Q., Groppo J., (2017). Flotation of monazite in the presence of calcite part I: Calcium ion effects on the adsorption of hydroxamic acid, Minerals Engineering, 100, 40-48.
ادامه مطلبThe floatability of scheelite and calcite in the presence of single depressant (SHMP or H3Cit) and mixed depressant (SHMP/H3Cit) was studied by microflotation experiments and artificial mixed mineral experiments. Solution chemical calculation, zeta potential tests, thermodynamic analysis and XPS analysis were used to explain the …
ادامه مطلب3.2. Mixed binary minerals flotation experiments. Flotation experiments on mixed binary minerals of calcite (1.0 g) and cassiterite (1.0 g) were carried out to evaluate the separation performance of different collector schedules using 4 mg/L CMC (See Table 1 of the Supplementary material available with this article). In cassiterite concentrate, …
ادامه مطلبFluorite (CaF2), as an important strategic mineral source, is usually separated from calcite by the common froth flotation method, but this separation is still not selective enough. The development of a …
ادامه مطلبFor the artificial mixed mineral te sts, 1 g of scheelite and 1 g of calcite were mixed into mixed minerals. After the mixed minerals were stirred fo r 1 min, the flo tation reagents were added.
ادامه مطلبAdvancing phosphate ore minerals separation with sustainable flotation reagents: An investigation into highly selective biobased depressants ... depression effect on apatite, calcite, dolomite, and quartz in different mineral systems. As illustrated in this table, calcite is the mineral that has been more studied among the four minerals and ...
ادامه مطلبFlotation is the most frequent beneficiation method for separating calcite from other minerals. The low selectivity for the calcite flotation separation is mainly due to its …
ادامه مطلب